當前位置：上海美盛自動化設備有限公司>>德國CMC Analytical instruments>>零空氣發生器

零空氣發生器

返回列表頁

參考價

面議

具體成交價以合同協議為準

產品型號零空氣發生器

品牌

廠商性質其他

所在地

在線詢價收藏產品查看聯系電話

聯系方式：仝先生查看聯系方式

更新時間：2023-08-10 19:01:09瀏覽次數：154次

聯系我時，請告知來自環保在線

產品分類 品牌分類

  德國CMC Analytical instruments

全部產品列表

暫無信息

上海美盛自動化設備有限公司

經營模式：其他

商鋪產品：149條

所在地區：

聯系人：仝先生

詢價 給他留言

產品簡介

零空氣發生器性能和益處:1,代替了代價高昂的危險氣瓶2,顯著地節省氣瓶3,安裝簡單，無特殊要求4,*的控制和安全系統的自動轉換開關5,滿足所有的標準和法規

詳細介紹

零空氣發生器
性能和益處:
1,代替了代價高昂的危險氣瓶
2,顯著地節省氣瓶
3,安裝簡單，無特殊要求
4,*的控制和安全系統的自動轉換開關
5,滿足所有的標準和法規

Zero-Air-Generators

Features & Benefits

Eliminates costly dangerous gas cylinders
Significant savings over cylinders
Simple installation, no special requirements
Constant purity with no fall off in performance
Sophisticated control and safety system with automatic changeover switch
Meets all standards and regulations

Technical Details

For GC-FID there are six new models in the SMART series to produce zero air of the highest possible purity from compressed air. All models are absolutely noiseless and easy to install. The generators continously produce zero-air with hydrocarbon content < 0,1 ppm (measured as methane). They cover requirements for zero-air for up to 160 FID´s at outlet pressures between 2 bar and 10 bar. Using modern filter technology to remove particles, water and oil-vapors, the generator works with your compressed air. The catalytical chamber stage than removes disturbing traces of hydrocarbon. Maximum air flow rate, gas/air supply, required temperature in the reactor and electrical requirements are checked and supervised continiously. If there is a fault or crossover of the critical values an alarm is given immediately via relays corresponding to ISO 9000. If the generators detect a fault they automatically switch over to back-up gas cylinders or cut off the gas delivery to the lab. The user can then eliminate the fault and reset the alarm. Even the biggest model delivers up to 50 l/min zero air of constant high purity, within 10 minutes of starting.

Benefits

Absolutely even base line in the apparatus, with practically no peaks.
Highest possible gas quality equivalent to UHP-gases; significant savings over gas cylinders.
Low inlet air pressure allows the generator to be located at point of use in the lab, i.e. where the pure gases are needed.
Enourmous saving of space and time.
Automatic switchover to back-up-cylinders when a fault is detected by the system.

Compressed air supply

All models of the SMART series are available with an external low noise and oil-less air compressor for permanent use (< 55 dbA).

Type	ZA 2000	ZA 4000	ZA 7500	ZA 20 K	ZA 35 K	ZA 50 K
Max. Air Flow Rate (ml/min)	2000	4000	7500	20000	35000	50000
Max. Inlet Hydrocarbon Concentr.	100 ppm (as CH4)
Outlet Hydrocarbon Concentration	< 0,1 ppm (as CH4)
Outlet Port (Swagelok)	Without display		With display
Electrical Requirements	230V/50Hz
Start Up Time	ca. 10 min.
Energy Consumption (W/h)	< 30	< 50	< 80	< 100	< 130	< 150
Power Take-Up (at switch-on)	420 W			1600 W
Dimensions (H x W x D)	270 x 340 x 460mm			330 x 460 x 560mm
Shipping Weight (kg)	13	15	19	25	28	32

Options

Flowmeter
Pressure-gauge
Temperature OK/stａnd by (LED view of catalyst)
Potentialfree contacts without hold-function
Voltage Failure
Failure Air/ Gas- Supply (1 to 8 bar adjustable)
Overheating in the Catalytical Chamber
Exceed of maximum
Flow Capacity
Potentialfree contacts with hold-function
Example: In case of "Failure Air/Gas-Supply", which means no pressure out of the compressor, immediately an alarm is given via relais. After elimination of the fault the alarm has to be quit manually and the generator starts service again.
Reaction to fault detection
gas delivery cut-off
automatic switchover to back-up cylinders